[1]梁岩,班亚云,罗小勇,等.不同荷载模式下锈蚀钢筋力学性能研究[J].地震工程与工程振动,2017,37(04):022-30.[doi:10.13197/j.eeev.2017.04.22.liangy.003]
 LIANG Yan,BAN Yayun,LUO Xiaoyong,et al.Study on mechanical performance of corroded reinforcement bar under different loading modes[J].EARTHQUAKE ENGINEERING AND ENGINEERING DYNAMICS,2017,37(04):022-30.[doi:10.13197/j.eeev.2017.04.22.liangy.003]
点击复制

不同荷载模式下锈蚀钢筋力学性能研究
分享到:

《地震工程与工程振动》[ISSN:/CN:]

卷:
37
期数:
2017年04期
页码:
022-30
栏目:
论文
出版日期:
2017-08-31

文章信息/Info

Title:
Study on mechanical performance of corroded reinforcement bar under different loading modes
作者:
梁岩1 班亚云1 罗小勇2 李杰1
1. 郑州大学 土木工程学院, 河南 郑州 450001;
2. 中南大学 土木工程学院. 湖南 长沙 410075
Author(s):
LIANG Yan1 BAN Yayun1 LUO Xiaoyong2 LI Jie1
1. College of Civil Engineering, Zhengzhou University, Zhengzhou 450001, China;
2. College of Civil Engineering, Central South University, Changsha 410075, China
关键词:
钢筋锈蚀重复荷载疲劳荷载力学性能
Keywords:
reinforcementsteel corrosioncyclic loadfatigue loadmechanical property
分类号:
TU511
DOI:
10.13197/j.eeev.2017.04.22.liangy.003
摘要:
基于不同荷载模式下锈蚀钢筋力学性能试验,分析了单调拉伸荷载、重复荷载及疲劳荷载作用下锈蚀钢筋的力学性能,对锈蚀钢筋力学性能在不同荷载模式下退化程度进行了对比研究,并给出了锈蚀钢筋力学性能退化计算式。试验表明,随着锈蚀率的增大,疲劳荷载及重复荷载下锈蚀钢筋力学性能退化比单调荷载下更为明显,伸长率及弹性模量退化相对严重,疲劳及重复荷载下锈蚀钢筋由软钢逐渐向硬钢转变,而坑蚀是导致这一现象的主要原因之一。坑蚀是应力集中源,同时也是锈蚀钢筋混凝土结构损伤累积源,建议对锈损结构疲劳及抗震性能评估应考虑这一因素的影响。
Abstract:
Through experiments of mechanical performance of corroded reinforcement bar under different loading modes, the effect of corrosion on mechanical property under monotonic tensile load, low cyclic load and fatigue load have been analyzed. Comparison of mechanical performance degradation of corroded reinforcement bar under different loading modes has been studied. Calculated mode for the mechanical performance degradation has been established. The conclusion showed that along with the accretion of rusty ratio, under low cyclic load and fatigue load, the mechanical performance degraded more seriously than that under monotonic tensile load. The degradation of elongation and elasticity modulus is comparatively serious, and the yielding plateau gradually shortened, and even disappears under low cyclic load and fatigue load. For this reason above all, pitting corrosion is where stress concentration and damage accumulation of corroded reinforcement concrete structure happen. Thus the influences of pitting corrosion should be taken into account while evaluate fatigue behavior and seismic performance.

参考文献/References:

[1] Abdullah A, Almusallam. Effect of corrosion on the properties of reinforcing steel bars[J]. Construct ion and Building Materials, 2001(5):361-368.
[2] Apostolopoulos, Alk C H. The influence of corrosion and cross-section diameter on the mechanical properties of B500c steel[J]. Journal of Materials Engineering and Performance. 2009, 18:190-195.
[3] 吴 庆, 袁迎曙. 锈蚀钢筋力学性能退化规律试验研究[J]. 土木工程学报, 2008, 41(12):42-47. WU Qing, YUAN Yingshu. Experimental study on the deterioration of mechanical properties of corroded steel bars[J]. China Civil Engineering Journal, 2008, 41(12):42-47. (in Chinese)
[4] 张伟平, 商登峰, 顾祥林. 锈蚀钢筋应力-应变关系研究[J]. 同济大学学报, 2006, 34(5):586-592. ZHANG Weiping, SHANG Dengfeng, GU Xianglin. Stress-strain relationship of corroded steel bars[J]. Journal of Tongji University, 2006, 34(5):586-592. (in Chinese)
[5] Apostolopoulos, Alk C H. Mechanical behavior of corroded reinforcing steel bars S500s tempcore under low cycle fatigue[J]. Construction and Building Materials 21, 2007:1447-1456.
[6] 张伟平, 李士彬, 顾祥林, 等. 自然锈蚀钢筋的轴向拉伸疲劳试验[J]. 中国公路学报, 2009, 22(2):53-58. ZHANG Weiping, LI Shibin, GU Xianglin, et al. Experiment on axial tensile fatigue of naturally corroded steel bar[J]. China Journal of Highway and Transport, 2009, 22(2):53-58. (in Chinese)
[7] 罗小勇, 梁 岩, 张艳芳. 重复拉伸荷载下锈蚀钢筋力学性能及本构关系研究[J]. 湖南大学学报, 2014, 41(11):81-86. LUO Xiaoyong, LIANG Yan, ZHANG Yanfang. Study on mechanical property and constitutive relation of corroded steel bars under tension cyclic loading[J]. Journal of Hunan University, 2014, 41(11):81-86. (in Chinese)
[8] 梁 岩, 罗小勇, 张艳芳. 重复荷载作用下锈蚀高强钢筋的性能变化[J]. 建筑材料学报, 2015, 18(1):145-149. LIANG Yan, LUO Xiaoyong, ZHANG Yanfang. Property changes of corroded high-strength steel bars under cycling load[J]. Journal of Building Materials, 2015, 18(1):145-149. (in Chinese)
[9] Luisa Berto, Renato Vitaliani, Anna Saetta, et al. Seismic assessment of existing RC structures affected by degradation phenomena[J]. Structual Safety, 2009(31):284-297.
[10] 李士彬, 汤红卫, 张 鑫. 锈蚀钢筋混凝土梁的疲劳性能[J]. 四川大学学报, 2014, 46(3):154-160. LI Shibin, TANG Hongwei, ZHANG Xin. Fatigue behavior of corroded reinforced concrete beams[J]. Journal of Sichuan University, 2014, 46(3):154-160. (in Chinese)
[11] 易伟建, 孙晓东. 锈蚀钢筋混凝土梁疲劳性能试验研究[J]. 土木工程学报, 2007, 40(3):6-10. YI Weijian, SUN Xiaodong. Experimental investigation on the fatigue behavior of corroded RC beams[J]. China Civil Engineering Journal, 2007, 40(3):6-10. (in Chinese)
[12] 易伟建, 孙晓东. 锈蚀钢筋疲劳后静力力学性能试验研究[J]. 工业建筑, 2007, 37(9):101-103. YI Weijian,SUN Xiaodong. Study on static mechanical property of fatigued corroded steel bass[J]. Industrial Architecture, 2007, 37(9):101-103. (in Chinese)
[13] 梁 岩, 罗小勇, 唐谢兴. 近海大气环境下钢筋混凝土构件抗震性能演化规律[J]. 华中科技大学学报, 2015, 43(8):14-19. LIANG Yan, LUO Xiaoyong, TANG Xiexing. Seismic performance evolution law of reinforced concrete member under offshore environment[J]. Journal of Huazhong University of Science and Technology, 2015, 43(8):14-19. (in Chinese)
[14] Gerstle W H, FEM M Xie. modeling of fictitious crack propagation in concrete[J]. Journal of Engineering Mechanics, 1992, 118(2):416-434.
[15] Hillerborg A, Modeer, Petersson P E. Analysis of crack formation and crack growth in concrete by means of fracture mechanics and finite elements[J]. Cement and Concrete Research, 1976(6):773-782.

相似文献/References:

[1]尚守平,周可威.复合隔震墩性能试验研究[J].地震工程与工程振动,2012,32(06):119.
 SHANG Shouping,ZHOU Kewei.Research on composite seismic isolation pier[J].EARTHQUAKE ENGINEERING AND ENGINEERING DYNAMICS,2012,32(04):119.
[2]祁皑,林云腾.添加钢筋提高隔震结构高宽比限值的研究[J].地震工程与工程振动,2005,25(01):120.
 Qi Ai,Lin Yunteng.Research on the approaches to increase the height-width ratio with supplemental steel bar[J].EARTHQUAKE ENGINEERING AND ENGINEERING DYNAMICS,2005,25(04):120.
[3]杨晓明,吴桐,李富斋.疲劳荷载作用后锈蚀钢筋混凝土梁承载力理论计算方法[J].地震工程与工程振动,2015,35(03):210.[doi:10.13197/j.eeev.2015.03.210.yangxm.026]
 YANG Xiaoming,WU Tong,LI Fuzhai.A theoretical method to calculate the load carrying capacity of corroded reinforced concrete beam after fatigue load[J].EARTHQUAKE ENGINEERING AND ENGINEERING DYNAMICS,2015,35(04):210.[doi:10.13197/j.eeev.2015.03.210.yangxm.026]

备注/Memo

备注/Memo:
收稿日期:2016-01-29;改回日期:2016-02-25。
基金项目:国家自然科学基金项目(51608488);河南省高等学校重点科研项目(16A560025)
作者简介:梁岩(1986-),男,讲师,博士,主要从事混凝土结构抗震、耐久性等方面研究.E-mail:LYFEEL555@163.com
更新日期/Last Update: 1900-01-01